Philadelphia Eagles fly with Fulcrum Acoustic
- Details
In 2017, the Stadium staff asked Diversified to design a new, upgraded audio system for the seating bowl. Diversified developed a comprehensive design, installed in multiple phases during off-seasons starting in spring of 2018.
The Philadelphia Eagles wanted to raise the bar for audio performance within the stadium. “The fan experience across the NFL has been improving for a number of years,” says Jeff Sanderson, senior design engineer at Diversified. “A lot of teams are renovating or building new stadiums. The Eagles wanted Lincoln Financial Field to sound as good or better than anything else in the NFL. Speech intelligibility and musical experience is a critical part of that.”
Diversified proposed a Fulcrum Acoustic-based solution for the system upgrade. Diversified had experience with Fulcrum products from other projects. Jeff Sanderson used EASE modelling software to design the new sound system incorporating AH, FH, and GX series products as well as Passive Cardioid subwoofers. Fulcrum’s ability to provide any model with weather resistant construction was also an important factor.
Rigging structures were prefabricated for fast installation. Fulcrum worked closely with Diversified to phase deliveries of products to the Stadium to keep the installation moving efficiently. Where possible, Diversified reused existing speaker locations and wiring. This reduced the amount of new wiring required, adding to the overall installation efficiency. To avoid conflicts with the Stadium’s schedule, the installation was to occur in the off-seasons and phased as follows:
The COVID delay of 2020 postponed a portion of that year’s work. Nevertheless Diversified did proceed with installation of approximately 160 customised loudspeakers to provide coverage for seats shaded from the main system.
Diversified installed 40 speaker clusters from the sunshade at the top of the stadium to provide audio distribution to the upper deck seats. Each cluster is comprised of 1 AH65 60° x 45° High Output Coaxial Horn and 2 GX1226 120° x 60° Coaxial Loudspeakers. The high output and long throw of Fulcrum’s AH Series loudspeakers provides coverage to the front half of the upper deck seats while the GX1226’s cover the seats below and behind the cluster locations. Additional AH96s and AH463s were installed to supplement coverage beyond the extent of the clusters.
Individual CS118 Subcardioid Subwoofers were installed between each cluster and aimed downward for low frequency support. The CS118’s Passive Cardioid design reduces rear low frequency radiation, thereby minimizing reflections off the roof structure for improved clarity.
The Club Level seats are located between the upper seating deck and lower level. For coverage here, Diversified used clusters of FH1565 60° x 45° coaxial horns and GX1226 loudspeakers attached to the underside of the Upper Deck overhang. The FH1565s provide coverage of the lower half of the Club Level seats while the GX1226s cover the seats near the clusters.
Loudspeakers for the Lower Level are mounted to the underside of the Club Level overhang. Clusters of AH65 and GX1226 are used to provide both long throw and near coverage, similar to the configurations used in the upper seating levels. CS118 subs were again selected for their combination of high-impact performance and low frequency control.
To better match the output and fidelity of the new system, Fulcrum developed the ESB44 and ESB31 horizontal arrays. These provide supplementary coverage for seats shaded from the main system.
The COVID-19 pandemic forced a realignment of the remaining phases of work. Work planned for 2021 will add new loudspeakers for the end zone seating using DX12 and CX8 series speakers. Additional custom ESB44 and ESB31 will be installed to complete the replacement of the existing fill speakers.
